Automotive Manual PDF

RSS Feed

The Resources for Automotive

1997-2003 Chevrolet C5 Corvette High Flow C5 Fuel Pump Module

September 18th, 2008 · No Comments

This high flow fuel pump module fits 1997 to 2003 model year Chevrolet Corvettes. During the 2003
model year GM made a change to the Corvette fuel system. This module will not fit the later 2003
vehicles. The 2003 model year C5 fuel system change over occurred on November 25, 2002. If your
car was built on or after this day, you have the newer fuel system and this module will not work in your
vehicle. If your car is a 2003 model year car and the last six (6) digits of VIN are 114930 or higher, you
have the newer fuel system and this module will not fit your vehicle. Look at page 3 of the instructions
for a picture of the 1997 to early 2003 model year fuel tank design (as seen from under the vehicle).

CAUTION: Before servicing any electrical component, the ignition key must be in the OFF or LOCK position and all electrical loads must be OFF, unless instructed otherwise in these procedures. If a tool or equipment could easily come in contact with a live exposed electrical terminal, also disconnect the negative battery cable. Failure to follow these precautions may cause personal injury and/or damage to the vehicle or its components.

WARNING: Before attempting installation of the new fuel pump module, ensure that the fuel tank is less than 1/8th full by checking the fuel level gauge. Even though the gauge may read empty, some residual fuel will be present in the tank. Exercise extreme caution and common sense when working around gasoline. Extinguish all open flame or other sources of ignition and be sure to perform the fol- lowing steps in an area with adequate ventilation. Personal protection in the form of safety glasses and fuel resistant gloves is strongly recommended.

Turn off ignition key and disconnect the negative battery terminal.
Vehicle will need to be raised to gain access to fuel tank. Raise the vehicle on an automotive lift or with jack stands at the points recommended by the manufacturer. Refer to the owners manual or a shop manual for further specifications. To avoid any vehicle damage, serious personal injury, or death, when major components are being removed from the vehicle and the vehicle is supported by a hoist, make sure to support vehicle with jack stands at the opposite end from which the components are being removed.

Get pdf 1997-2003 Chevrolet C5 Corvette High Flow C5 Fuel Pump Module

Related Entries


Related Tags: , , , , , , , , , , , , , , , , , , ,


Related Keyword: hw many volts is nissan murano 2003 fuel pump 2003model, 2001 corvette fuse box diagram, changing 1999 corvette fuel pump, how to change fuel pump in 200 corvette, how to change fuel pump om a 1999 corvette

0 comments for this entry ↓

  • There are no comments yet for this entry.

You must log in to post a comment.