Automotive Manual PDF

RSS Feed

The Resources for Automotive

Entries Tagged as 'Volvo'

QL Boat trim system User and Installation Instructions

December 21st, 2008 · No Comments

This batch with its accompanying instructions is produced for Volvo Penta’s service workshops, boat-builders, machine manufacturers and other authorized workshops which have personnel with qualified professional training.

The installation instructions are only produced for professional use and are not intended for non-professional use. Volvo Penta will not assume any liability whatsoever for damage incurred, either damage to materials or personal injury, which may result if the installation instructions are not followed or if the work is carried out by non-professional personnel.
(more…)

[Read more →]

Volvo 760 and 740 Radio Install

December 19th, 2008 · No Comments

This vehicle most likely has an external amplifier powering the speakers, not the amplifier inside the radio. This creates problems when installing a new replacement radio. The Volvo amplifier cannot be used and must be bypassed. This document shows you the extensive steps to remove the auto makers radio, find and bypass the auto makers amplifier in the vehicle, and then connect and mount the new replacement radio. If you have 4 speakers in your vehicle (2 in the front doors, and 2 in the rear doors) you most likely have an amplifier in your vehicle.
(more…)

[Read more →]

VOLVO i-shift Overdrive, for Volvo D11, D13 Operator’s Manual

December 17th, 2008 · No Comments

The Volvo I-Shift transmission is a single countershaft transmission with 12 forward gears and two reverse gears. Some vehicles have four reverse gears. The I-Shift is an automated mechanical transmission. The transmitted torque (both engine and braking) will be interrupted during gear shifting, in both driving and coasting conditions. There is no clutch pedal and the gearshift is controlled by the ergonomic gear selector. The I-Shift is available as an overdrive or direct drive transmission.
(more…)

[Read more →]

VOLVO F-12 GlobeTrotter

December 15th, 2008 · No Comments

When designing their trucks, Volvo takes many factors into consideration. Safely is one of these factors and is extremely important to Volvo. Volvo’s truck cabs must not only be able .to withstand over seven tons placed on its top, but afterwards, the cab doors must still open. The bumper of the F-I2 has been designed so that it is low enough to prevent a car from becoming wedged underneath in the event of a collision. Driver comfort is also an important consideration of Volvo’s designers.
(more…)

[Read more →]

Volvo Trucks Service Manual

December 14th, 2008 · No Comments

The descriptions and service procedures contained in this manual are based on design and method studies up to September 1991. The products are under continuous development. Vehicles and components produced after the above date may therefore have different specifications and repair methods. When this is judged to have a significant bearing on this manual, supplementary service bulletins will be issued to cover the changes. The new edition of this manual will update the changes.
(more…)

[Read more →]

Super Pro Polyurethane Bushings on 240 Series Volvos Installation Manual

December 13th, 2008 · No Comments

I installed a set of Super Pro bushings in my 1980 Volvo 244, using suspension components from mixed donor cars: some were from a 1977 242 DL, some were from a 1979 242 GT, and some were from a 1984 245 DL. Though these vehicles are very different, installation should be typical since none of them used parts specific to that model.
(more…)

[Read more →]

Volvo V70 2.4 Complete Report Manual

December 12th, 2008 · No Comments

Volvo does station wagons right. The V70, introduced in 2001, offers styling that is fresh and contemporary without compromising practicality-a maximum of 72 cubic feet of cargo fits in back. Of course there are all the safety features you expect in a Volvo, including whiplash-reducing seats and both side and curtain airbags. The V70 comes in standard front-drive or all-wheel-drive versions, powered by a range of 2.3-, 2.4-, or 2.5-liter five-cylinder engines, with or without turbocharging. The taller-riding, rugged-looking XC70 model and a 300-hp, six-speed V70R model with variable damping and Haldex all-wheel drive round out a full model range. Retuned steering, new side-view mirrors and dash gauges, and a few subtle trim changes are all that’s new for ‘04. The V70’s value, power, practicality, and safety continue to win over tough customers.
(more…)

[Read more →]

Volvo Penta MD5A Marine diesel engine Workshop Manual

December 11th, 2008 · No Comments

This workshop manual contains repair instructions for the MD5A marine diesel engine. The instructions concerning overhauling describe the most suitable working method to be used with the special tools listed under the heading “Special tools”. Both the engine designation and its serial number must be clearly stated in all correspondence concerning the engine and when ordering spare parts. We reserve the right to carry out design modifications and, for this reason, the contents of this manual cannot he regarded as binding.
(more…)

[Read more →]

Volvo Pental MD11C, D, MD17C, D Engines Workshop Manual

December 11th, 2008 · No Comments

This workshop manual contains technical specification, descriptions and instructions for repairing the standard versions of the following engines MD11C, D, MD17C, D. The workshop manual displays the operations carried out on any of the engines above. As a result the illustrations and pictures in the manual that show certain parts on the engines, do not in some cases apply to all the engines listed above. However the repair and service operations described are the same in all essential details. Where they are not the same this is stated in the manual and where the difference is considerable the operations are described separately. Engine designations and numbers are given on the number plate (See page 9). The engine designation and number should be given in all correspondence about the engine.
(more…)

[Read more →]

Volvo Headlight Cover Installation

December 11th, 2008 · No Comments

Headlamp guard
Installation
1 – Open the bonnet
- Clean the headlamp lens
- Take the mounting strips for the headlamp guards from the kit
- Pry up the weatherstrip for the headlamp. Use a plastic weatherstrip tool
- Insert the mounting strip between the top of the headlamp and the weatherstrip. Position the mounting strip as illustrated. (more…)

[Read more →]