Automotive Manual PDF

Vehicles are equipped with an integral housing steering rack that is sealed and must be replaced if defective.
FLUID LEVEL CHECK
Check fluid level when fluid is cold with engine off. To check and fill, remove fluid level gauge from reservoir and check fluid level. Fluid level should be between MIN and MAX marks on gauge dipstick. Add fluid through dipstick opening as needed, and recheck fluid level. DO NOT overfill.
(more…)

[Read more →]

New C70
• The new C70 is a new coupé/convertible that replaces the previous C70 models
• The C70 has a new design, the car is based on the S40/V50 and at the same time has many of the characteristics and functions found in these cars.
• The C70 has a lot of new technology but much of the technology is in principle the same as in the S40/V50.
(more…)

[Read more →]

1. Remove negative battery cable, then positive battery cable from the battery. If equipped, the Supplemental Restraint System will be deactivated when the battery is disconnected.
STEERING
2. Lock the steering wheel.
3. Located under the dash, remove the bolt that connects the steering shaft universal joint to the steering column and separate the steering shaft from the steering column.
(more…)

[Read more →]

The center position of the fanfare horns and airbag clock spring contact (A45) is crucial for the trouble-free function of the airbag system and signaling system. In the removed condition, the position is ensured by the mounting screws (32h).
If contact spiral is twisted, however, e.g.
- When the steering coupling is removed
- When the retaining bolts are fully unscrewed then the center position must be found as follows:
(more…)

[Read more →]

The Supplemental Restraint System (SRS) is designed to operate when vehicle strikes a rigid or heavy object with enough force to activate SRS. Activation impact area is directly in front of vehicle and 30 degrees on either side of dead center. SRS is not designed to activate during a side or rear collision, a rollover, or a frontal collision at low speed or with soft objects. In addition, the 850 is equipped with Side Impact Protection System (SIPS). SIPS are seat mounted air bags which deploy only in the event of a side impact intrusion in the front passenger compartment.
(more…)

[Read more →]

Exercise extra care when carrying out repair work on cars equipped with SRS (Supplemental Restraint System)/SIPS. This is to help prevent:
1. Personal injury during the repair work.
2. Damage or function impairment in the

SRS/SIPS systems. Any work on the SRS/SIPS systems or related components in the car which could effect the SRS/SIPS systems must be carried out by an authorized Volvo workshop. Read the SRS and SIPS service manuals if in doubt.
(more…)

[Read more →]

As the popular Mirage disappears from Mitsubishi’s local line-up, the Colt nameplate returns, ready to battle it out in the premium small car sector. Its stylish “mono-box” design, (more compact people mover than hatchback), features a panoramic front screen and upright abbreviated tail. Only one drivetrain is on offer for our market – the 1.5litre MIVEC four cylinder mated to Mitsubishi’s automatic INVECS III CVT (continuously variable transmission).
(more…)

[Read more →]

Removing steering column switch
Driver’s side airbag unit and steering wheel removed.
- Pull out steering column and tilt downward as far as it will go.
- Remove screws -1-(2x). Tightening torque: 2.8 Nm (25.2 in lb)
- Remove grip - 2-.
- Remove two Phillips-head screws -arrows-. Tightening torque: 0.6 Nm (5.4 in lb)
- Remove upper steering column switch trim -1-.
When installing, insert upper section into hooks on lower section, swivel downward and secure with screws
(more…)

[Read more →]

AUDIO
Audio, integrated unique fit with Liquid Crystal Display CD Autochanger, under seat mounted
Speakers - 6
Audio controls, steering wheel mounted.
Radio Aerial, glass integrated
AM/FM radio with preset settings
RDS with PTY and EON settings
CD Player, single disc
(more…)

[Read more →]

Grades Available XT3 XT-R XT4 XT5 T180
AUDIO
Audio, integrated unique fit with Liquid Crystal Display
AM/FM radio with preset settings
RDS with PTY and EON settings
CD Player, single disc - -
6 Disc CD autochanger, dashboard mounted - - -
MP3/WMA reader
(more…)

[Read more →]