Automotive Manual PDF

RSS Feed

The Resources for Automotive

VW GOLF IV/JETTA Supplemental Installation Information

August 17th, 2008 · No Comments

Overview of process
1. Mount Heating Unit
2. Run wiring harness into vehicle
3. Connect coolant hoses
4. Mount fuel pump and run fuel lines
5. Route wires inside vehicle and make final connections
6. Tap fuel via sending unit
(more…)

[Read more →]

2001 VW Golf TDI Gauge Installation

August 14th, 2008 · No Comments

This page describes my aftermarket gauge install on my 2001 VW Golf TDI. It should directly apply to any Mk4 (99.5+) Golf or Jetta TDI and it should apply to the 98+ New Beetle TDIs. For other engines, wiring should be similar, but the installation of senders into the engine will be different. The intention of this page is to share information about my install and to help others who are considering an install. I tried to photograph everything important. Shoot me an email if you can think of a photo that you’d like to see that I haven’t included. In fact, any comments are welcome.
(more…)

[Read more →]

VW Golf & Jetta Service and Repair Manual

May 5th, 2008 · No Comments

VW Golf & Jetta Mk 2 models with petrol engines, including fuel injection, catalytic converter, Formel E, 16-valve and special/limited edition models 1043 cc, 1272 cc, 1595 cc & 1781 cc Covers mechanical features of Van. Does not cover Convertible, Rallye, Caddy, diesel engine, 4 -wheel drive, Mk 1 models or new Golf range introduced in February 1992 I M Coomber and Christopher Rogers
(more…)

[Read more →]

VW Golf & Jetta Service and Repair Manual

April 9th, 2008 · No Comments

The Mk. II Volkswagen Golf and Jetta range of models was introduced in March 1984, revised body and trim features being the main visual difference to the earlier range of models. The engine/transmission is mounted transversely at the front of the vehicle, drive being to the front wheels. Detailed improvements have been made throughout the years of manufacture to improve power output and economy.
(more…)

[Read more →]

VW Golf and Jetta Braking System Manual

April 9th, 2008 · No Comments

Fairly easy, suitable for beginner with some experience, Fairly difficult, suitable for competent DIY mechanic 3 Difficult, suitable for experienced DIY mechanic 4 Very difficult, suitable for expert DIY or professional 5 Specifications Brake system Type Hydraulic, dual circuit, split diagonally, pressure regulator on some models. Disc front brakes. Drum or disc rear brakes. Cable-operated handbrake on rear wheels. Front brakes Disc thickness: New: 1.05 and 1.3 litre 1.6 and 1.8 litre 1.8 litre with ventilated discs Minimum: 1.05 and 1.3 litre 1.6 and 1.8 litre 1.8 litre with ventilated discs Pad thickness: New – excluding backplate: 1.05 and 1.3 litre 1.6 and 1.8 litre 1.8 litre with ventilated discs Minimum – including backplate: All models 10.0 mm 12.0 mm 20.0 mm 8.0 mm 10.0 mm 18.0 mm 12.0 mm 14.0 mm 10.0 mm 7.0 mm
(more…)

[Read more →]

VW Golf III / Jetta III Wiring Diagram Manual

April 9th, 2008 · No Comments

Main wiring diagram, 2.8L Gas Engine, Engine Code AAA Note: For A/C system wiring information for vehicles equipped with the 2.8L Gas Engine, code AAA, see Index for correct Wiring Diagram No. Relay locations Positions of relays and multi-pin connector wiring, see also “Component Locations” sections. Load Reduction Relay Emergency Flasher Relay Wiper / Washer Intermittent Relay Seat Belt Warning System Relay Dual Horn Relay Fuel Pump Relay
(more…)

[Read more →]